采用湿化学法制备了锑掺杂氧化锡Sn1-xSbxO2-δ（ATO,x=0.003、0.005、0.007和0.01）粉体材料,并以Li2O-TiO2为助烧剂,用传统烧结工艺制得ATO陶瓷。利用X射线衍射分析了材料的相组成,扫描电子显微镜观察陶瓷的微观结构,通过电阻-温度特性测试仪和交流阻抗谱研究了ATO陶瓷导电性随温度的变化。结果表明,ATO材料具有四方晶体结构;1200℃烧结获得致密度为95%以上的陶瓷试样。该陶瓷材料呈现典型的电阻负温度系数效应。利用能带理论和电子跃迁模型讨论了ATO陶瓷的导电机理。
Sn1-xSbxO2-δ（ATO,x=0.003、0.005、0.007 and 0.01） powders were prepared by a wet-chemical synthesis process,and the corresponding ceramics were obtained by the conventional sintering technique with Li2O-TiO2 as the sintering additive.The phase component of the prepared materials was analyzed by using X-ray diffractometry and the ceramic microstructures were observed by scanning electron microscopy.The temperature dependence of resistivity of the ATO ceramics was investigated with the resistance-temperature measurement system and AC impedance analysis.The results show that the ceramics with a relative density of higher than 95% can be obtained by sintering at 1200℃,and the ceramics have a tetragonal crystal structure and show a typical effect of negative temperature coefficient of resistivity.The conduction mechanisms of the ATO ceramics were discussed by using energy band theory and electron hopping model.
参考文献
| [1] | M. Vakiv;I. Hadzaman;O. Shpotyuk et al.On the role of mass-transfer processes in ageing of manganite electroceramies[J].Journal of the European Ceramic Society,2004,24(06):1277-1280. |
| [2] | K. Park;J. K. Lee.J. electrical stability of substituting Cr203 for Compounds, 2007, 437 G. Kim, S. Nahm. Improvement in the Mn-Ni-Co-O NTC thermistors by Co30[J].Journal of Alloys and(1-2):211-214. |
| [3] | J. G. Fagan;V. R. W. Amarakoon;R. W. Vasantha .Reliability and reproducibility of ceramic sensors. I-NTC thermistors[J].American Ceramic Society Bulletin,1993,72(01):70-79. |
| [4] | 汪健,王申存,张鸿,李志成.钴掺杂对钛酸钡陶瓷晶体结构与电性能的影响[J].硅酸盐学报,2009(03):354-358. |
| [5] | 汪健;张鸿;张哲;李志成 .六方晶系BaTi0.8Co.2O3-8新型NTC热敏材料[J].材料科学与工程学报,2009,27(04):1-4. |
| [6] | Ying Luo;Xinyu Liu .High temperature NTC BaTiO_3-based ceramic resistors[J].Materials Letters,2005(29/30):3881-3884. |
| [7] | J. Wang;H. Zhang;D. Xue;Z.C.Li .Electrical properties of hexagonal BaTi0.8Co0.203-a ceramic with NTC effect[J].Journal of Physics D; Applied Physics,2009,42(23):235103. |
| [8] | 郭玉忠,王剑华,黄瑞安,王贵青.掺杂SnO2透明导电薄膜电学及光学性能研究[J].无机材料学报,2002(01):131-138. |
| [9] | Jaswinder Kaur;V.D. Vankar;M.C. Bhatnagar .Role of surface properties of MoO_3-doped SnO_2 thin films on NO_2 gas sensing[J].Thin Solid Films: An International Journal on the Science and Technology of Thin and Thick Films,2010(14):p.3982. |
| [10] | S. Y. Vassiliev;V. K. Laurinavichute;A. M. Abakumov et al.Mierostructural aspects of the degradation behavior of SnO2based anodes for aluminum electrolysis[J].Journal of the Electrochemical Society,2010,157(05):C178-C186. |
| [11] | 朱振峰,黄剑锋,曹丽云.SnO2基NTC热敏陶瓷性能及结构的研究[J].武汉理工大学学报,2002(08):16-18,27. |
| [12] | 李亚东,朱宏,丁古巧.玻璃助剂对厚膜NTC热敏电阻器材料特征常数的影响[J].材料科学与工程学报,2004(06):823-826. |
| [13] | P. N. Hari;V. V. Anil .Low-TemperatureTiO2-SnOz Phase Diagram Using the Molten-Salt Method[J].Journal of the American Ceramic Society,1998,81(08):2176-2180. |
| [14] | D. W. Yuan;S. F. Wang;W. Huebner;G.Simkovich .The effect of Li-salt additions on the densification of tin oxide[J].Journal of Materials Research,1993,8(07):1675-1679. |
| [15] | 王卫民,赵鸣,张慧君,高峰,田长生.NTC热敏电阻材料组成及制备工艺研究进展[J].材料科学与工程学报,2005(02):286-289. |
| [16] | A. Svane;E. Antoncik .Electronic structure of rutile SnO2, GeO2 and TeO2[J].Journal of Physics and Chemistry of S,1987,48(02):171-180. |
| [17] | M. K. Paria;H. S. Maiti .Electrical conductivity and defect structure of polyerystalline tin dioxide doped with antimony oxide[J].Journal of Materials Science,1982,17:3275-3280. |
| [18] | 薄占满 .掺Sb二氧化锡半导体导电机理的实验探讨[J].无机材料学报,1990,5(04):324-329. |
| [19] | Z. M. Jarzebski;J. P. Marton .Physical Properties of SnO2 Materials[J].Journal of the Electrochemical Society,1976,123(09):299C-310C. |
| [20] | M. A. L. Nobre;S. Lanfredi .Grain boundary electric characterization of ZnTSb2012 semiconducting ceramic: A negative temperature coefficient thermistor[J].Journal of Applied Physics,2003,93(09):5576-5582. |
| [21] | M. A. L. Nobre;S. Lanfredi .Thermistor ceramic with negative temperature coefficient based on Zn_(7)Sb_(2)O_(12): An inverse spinel-type phase[J].Applied physics letters,2002(3):451-453. |
| [22] | R. Schmidt;A. Basu;A. W. Brinkman .Small polaron hopping in spinel manganates[J].Physical review, B. Condensed matter and materials physics,2005(11):115101.1-115101.9. |
| [23] | A. K. Jonseher .Review: The 'universal' dielectric response[J].Nature,1977,267:673-679. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%