本文采用热丝化学气相沉积法在不同灯丝温度(1650 - 1850℃)下沉积了p型氢化纳米晶硅薄膜,研究了灯丝温度对薄膜微结构、光学性能及电学性能的影响.结果表明,随着灯丝温度的升高,薄膜的晶化率先增大后略微减小,最大值是55.5％.载流子浓度和霍尔迁移率先分别从5×1017 cm-3和0.27 cm2/V·s增加到1.32×1020 cm-3和0.43 cm2/V·s后略微减小,同时电导率从0.02 S/cm显著增加到8.95 S/cm,而电导激活能则从271.5 meV急剧减小至25 meV.
参考文献
| [1] | Das D;Bhattacharya K .Characterization of the Si:H Network During Transformation from Amorphous to Micro-and Nanocrystalline Structuros[J].Journal of Applied Physics,2006,100:103701. |
| [2] | Seto J Y W .The Electrical Properties of Polycrystalline Silicon Films[J].Journal of Applied Physics,1975,46(12):5247-5254. |
| [3] | 徐刚毅;王天民;何宇亮 等.纳米硅薄膜的低温电输运机制[J].物理学报,2000,49:1798. |
| [4] | Saleh R.;Nickel NH. .Raman spectroscopy of B-doped microcrystalline silicon films[J].Thin Solid Films: An International Journal on the Science and Technology of Thin and Thick Films,2003(1/2):266-269. |
| [5] | Gogoi P;Jha H S;Agarwal P .High Band Gap Nanocrystallite Embedded Amorphous Silicon Prepared by Hot-wire Chemical Vapeur Deposition[J].Thin Solid Films,2010,518:6818-6828. |
| [6] | Gogoi P;Jia H S;Agarwal P .Variation of Microstructure and Transport Properties with Filament Temperature of HWCYD Prepared Silicon Thin Films[J].Thin Solid Films,2011,519:4506-4510. |
| [7] | Michael M. Adachi;Karen L. Kavanagh;Karim S. Karim .Structural and electrical characteristics of nanocrystalline silicon prepared by hot-wire chemical vapor deposition on polymer substrates[J].Thin Solid Films: An International Journal on the Science and Technology of Thin and Thick Films,2008(21):7418-7421. |
| [8] | P. A. T. T. van Veenendaal;R. E. I. Schropp .Processes in silicon deposition by hot-wire chemical vapor deposition[J].Current opinion in solid state & materials science,2002(5):465-470. |
| [9] | Akihisa Matsuda .Growth mechanism of microcrystalline silicon obtained from reactive plasmas[J].Thin Solid Films: An International Journal on the Science and Technology of Thin and Thick Films,1999(1/2):1-6. |
| [10] | H. Chen;M.H. Gullanar;W.Z. Shen .Effects of high hydrogen dilution on the optical and electrical properties in B-doped nc-Si:H thin films[J].Journal of Crystal Growth,2004(1/2):91-101. |
| [11] | 于军,王晓晶,雷青松,彭刚,徐玮.沉积压力对磁控溅射纳米硅薄膜结构和性能影响[J].人工晶体学报,2009(03):556-560. |
| [12] | Mahan AH;Biswas R;Gedvilas LM;Williamson DL;Pan BC .On the influence of short and medium range order on the material band gap in hydrogenated amorphous silicon[J].Journal of Applied Physics,2004(7):3818-3826. |
| [13] | Shimakawa K. .Percolation-controlled electronic properties in microcrystalline silicon: effective medium approach[J].Journal of Non-Crystalline Solids: A Journal Devoted to Oxide, Halide, Chalcogenide and Metallic Glasses, Amorphous Semiconductors, Non-Crystalline Films, Glass-Ceramics and Glassy Composites,2000(Pt.A):223-226. |
| [14] | Song, C.;Xu, J.;Wang, Q.;Zha, G.;Li, W.;Chen, K. .Carrier transport of doped nanocrystalline Si formed by annealing of amorphous Si films at various temperatures[J].Solid State Communications,2011(9):697-700. |
| [15] | 陈庆东;王俊平;张宇翔 等.磷掺杂微晶硅薄膜激活能特性研究[J].人工晶体学报,2010,39(01):135-138. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%