采用Tafel直线外推法、交流阻抗和加速腐蚀试验,研究了拉伸应力作用下高强度镀锌钢丝在不同温度的模拟酸雨溶液中的腐蚀行为,表征其腐蚀前后形貌.结果表明:1100 MPa拉伸应力作用下镀锌钢丝于60℃模拟酸雨溶液中的腐蚀速率为27.6μA/cm~2,较室温下腐蚀速率增加31%;腐蚀产物南多孔膜状变为颗粒状堆积于微孔处:1100 MPa拉伸应力作用下镀锌钢丝于50℃盐雾腐蚀试验环境中的腐蚀速率为4.3 mg/dm~2·d,较35℃时增加19%.
Corrosion behavior of high strength galvanized steel wires under certain tensile stress was stud-ied at different temperatures in a simulated acid rain by Tafel linear extrapolation, EIS and accelerated corrosion test. Morphologies of the steel wires after corrosion in the simulated acid rain were characterized by SEM. Results showed that corrosion current density of the steel wire under 1100 MPa tensile stress in simulated acid rain at 60℃ was 27.6 μA/cm~2 ,had an increase of 31% in conrparison with that at room temperature. With increasing of temperature, white grainula-like corrosion product formed in the region of micro pores on the steel wire surface, while at room temperature a white film covered the steel wire. Accel-erated corrosion test results showed that the corrosion rate of the steel wire was 4.3mg/dm~2·d in acid fog at 50℃ ,which is 19% higher than that corroded at 35℃.
参考文献
| [1] | Mayrbaurl R M,Camo S.Cracking and fracture of suspension bridge wire[J].Journal of Bridge Engineering,2001,6(6):645. |
| [2] | 黄跃平,胥明,姜益军,等.缆索局部腐蚀检测与评估分析[J].腐蚀科学与防护技术,2006,18(2):132. |
| [3] | 王力力,易伟建.斜拉索的腐蚀案例与分析[J].中南公路工程,2007,32(1):93. |
| [4] | Bloomstine,M,Sorensen O,Thomsen J.Conference on Operation,Maintenance and Rehabilitation of Large Infrastructure Projects:Main Cable Corrosion by dehumidification[C].Denmark:Copenhagen,2006.216. |
| [5] | Suzumura K,Nakamura S.Environmental factors affecting corrosion of galvanized steel wires[J].Journal of Materials in Civil Engineering,2004,16 (1):1. |
| [6] | Yanaka Y,Kitagawa M.Maintenance of steel bridges on honshu-shikoku erasing[J].Journal of Constructional Steel Research,2002,58:131. |
| [7] | Betti R,West A C,Vermaas G,et al.Corrosion and embrittlement of high-strength steel bridge wires[J].Journal of Bridge Engineering,2005,10 (2):151. |
| [8] | 黎学明,刘强,孔令峰,等.模拟酸雨溶液中应力对镀锌钢绞线腐蚀行为影响[J].腐蚀科学与防护技术,2008,20(1):44. |
| [9] | Barton S C,Vermaas G W,Duby P F,et al.Accelerated corrosion and embrittlement of high-strength bridge wire[J].Materials in Civil Engineering,2000,12(1):33. |
| [10] | Miyata Y,Asakura S.Oxygen reduction reaction at rust free iron surface in neutral unbuffered chloride solutions[J].Corrosion Science,2002,44:589. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%