用水热法制备出了纳米级粒径的纤维状KAl(OH)2CO3,并研究了不同水热反应条件对KAl(OH)2CO3的形成、颗粒度以及形态的影响.研究表明,不同条件下合成的晶粒均呈纤维状,随着温度的升高,长度和粒径均有所增大.在120℃制备得到的纤维平均直径为30nm,且分布均匀;KHCO3和Al(OH)3之比对KAl(OH)2CO3的形貌有显著的影响,KHCO3用量越大,晶粒直径越细;随着介质碱性的增强,晶粒直径在pH为9.5时出现极小值,且粉体的均匀性最好.在特定的反应体系中,当反应时间达到2h后,合成反应基本达到平衡,进一步延长合成时间对粉体的形貌和颗粒尺寸没有明显的影响
KAl(OH)2CO3 powder was prepared by a hydrothermal method using Al(OH)3 and KHCO3 as the starting material.
The influence of the composition of the starting material, reaction temperature, acidity of the reaction medium and reaction time on the formation, morphology
and particle size of KAl(OH)2CO3 powder was systematically investigated. The research results show that fibrous particles will be obtained at most
conditions. The length and diameter of particles increase with the ratio of Al(OH)3 to KHCO3 or the reaction temperature increasing. The
morphology and particle size of the products are significantly affected by the acidity of the reaction system, and pH=9.5 is optimal for the preparation
of the KAl(OH)2CO3 powder with minimal diameter and the best uniformity.
参考文献
| [1] | Hernandez M J, Ulibarri M A. Thermochim Acta. 1985, 94 (2): 257--266. [2] Frueh A J, Golightly J P. Can. Minaral, 1967, 6 (3): 51--56. [3] Corazza E, Sabelli C, et al. Neues Jahrb Minaral. Monatsch., 1977, 49 (10): 381--385. [4] Ahmad A, Wheat T A, et al. Solid State Ionics 1994, 68 (5): 233--239. [5] 徐衍彬, 陈平, 徐永成. 石油与天然气地质, 1994, 15 (4): 322--326. [6] 施尔畏, 夏长泰, 等(SHI Er-Wei, et al). 无机材料学报(Journal of Inorganic Materials), 1996, 11 (2): 193--206. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%