以喷雾造粒 ＺｒＯ２粉料为研究对象，通过对粉料的压力－密度曲线及坯体的 ＳＥＭ显微结构分析，发现喷雾造粒粉料的粒度分布对坯体密度的影响较小；颗粒强度的大小是获得均匀的坯体结构的关键，颗粒的强度与其大小及环境湿度有关，因此颗粒适当的增塑及去除大颗粒均有利于坯体显微结构的改善．
The green compact properties of ZrO2 spray-dried powders were studied by means of pressure-density compaction
curves of the powder and SEM photographs．The results show found that the granule size distribution of the spray-dried powder has a smaller effect on the green compact density．
Granule yield strength, which depends on the dimension of granules and the relative humidity in the environment, is a critical factor influencing the
uniformity of green compact microstructures．Therefore, plasticizing granules and eliminating larger granules can improve the microstructure
of the green compact．
参考文献
| [1] | 卢旭晨, 徐廷献, 等．硅酸盐学报, 1997, 25 (3): 364--367. [2] Dynys F W, Halloran J W． J. Am. Ceram. Soc., 1983, 66 (9): 655--659. [3] Messing G L, Markhoff C J, Mccoy L G． Am. Ceram. Soc. Bull., 1982, 61 (8): 857--860. [4] 李懋强, 迟卓男．硅酸盐学报, 1990, 18 (10): 406--411. [5] Lukasiewicz S J, Reed J S． Am. Ceram. Soc. Bull., 1978, 57 (9): 798--801. [6] Lange F F, Metcalf M． J. Am. Ceram. Soc., 1983, 66 (6): 398--406. [7] Dynys F W, Halloran J W． J. Am. Ceram. Soc., 1984, 67 (9): 596--601. [8] Lange F F． J. Am. Ceram. Soc., 1984, 67 (2): 83--87. [9] Rhodes W H． J. Am. Ceram. Soc., 1981, 64 (1): 19--22. [10] Dimilia R A, Reed J S． Am. Ceram. Soc. Bull., 1983, 62 (4): 484--488. [11] Toyoshima K．In: Polyvinyl Alcohol-Properties and Applications. New York: 1973. 339. [12] Nies C W, Messing G L． J. Am. Ceram. Soc., 1984, 67 (4): 301--304. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%