研究了施加掺杂铁红粉的环氧涂层的Al在3.5 mass%Nacl溶液(模拟海洋环境)中的电化学阻抗谱(EIS)随浸泡时间的变化,提出了两种基于高频EIS测试数据的侠速评价涂层防护性能方法:局部拟合涂层电阻法和修正的特征频率法.结果表明,虽然局部拟合所得的涂层电阻值与全谱拟合所得值有一定偏差,但它们的变化趋势吻合,且很好反映了涂层的失效过程,说明局部拟合涂层电阻的方法有望被用于涂层防护性能的监检测.此外,针对传统涂层快速评价所用的特征频率法未考虑涂层电容弥散效应的不足,提出了考虑涂层电容弥散效应时特征频率的修正方法.实验观察到,在涂层浸泡过程中涂层电容对应的n值逐渐下降,而修正值与传统特征频率值差别也越来越大,说明在涂层防护性能监检测中对传统特征频率法进行修正十分必要.
参考文献
| [1] | Zhu D,van Ooij W J.Corrosion protection of metals by waterbased silane mixtures of bis-[trimethoxysilylpropyl]amine and vinyltriacetoxysilane[J].Prog.Org.Coat.,2004,49:42. |
| [2] | 曹楚南,张鉴清.电化学阻抗谱导论[M].北京:科学出版社,2002. |
| [3] | Zhang J T,Hu J M,Zhang J Q,et al.Studies of water transport behavior and impedance modals of epoxy-coated metals in NaCl solution by EIS[J].Prog.Org.Coat.,2004,51:145. |
| [4] | Ji W G,Hu J M,Liu L,et al.Improving the corrosion performance of epoxy coatings by chemical modification with silane monomers[J].Surf.Coat.Technol.,2007,201:4789. |
| [5] | Brasher D M,Kingsbury A H.Electrical measurements in the study of immersed paint coatings on metal.Ⅰ.Comparison between capacitance and gravimetric methods of estimating water uptake[J].J.Appl.Chem.,1954,4:62. |
| [6] | Castela A S,Simoes A M.An impedance model for the estimation of water absorption in organic coatings.Part Ⅱ:A complex equation of mixtures[J].Corros.Sci.,2003,45:1647. |
| [7] | Deflorian F,Fedrizzi L,Bonora P L.Influence of the photo-oxidative degradation on the water barrier and corrosion protection properties of polyester paints[J].Corros.Sci.,1996,38:1697. |
| [8] | Barranco V,Carpentier J,Grundmeier G.Correlation of morphology and barrier properties of thin microwave plasma polymer films on metal substrate[J].Electrochim.Acta,2004,49:1999. |
| [9] | Castela A S,Simoes A M.An impedance model for the estimation of water absorption in organic coatings.Part Ⅰ:A linear dielectric mixture equation[J].Corros.Sci.,2003,45:1631. |
| [10] | Castela A S,Simoes A M.Assessment of water uptake in coil coatings by capacitance measurements[J].Prog.Org.Coat.,2003,46:55. |
| [11] | Neshati J,Fardi M R.Evaluation and investigation of surface treatment of industrial coatings by impedance spectroscopy[J].Surf.Eng.,2004,20:299. |
| [12] | Sykes J M.A variant of the brasher-kingsbury equation[J].Corros.Sci.,2004,46:515. |
| [13] | Haruyama S,Asari S,Tsuru T.Corrosion protection by organic coatings[J].Electrochem.Soc.,1987,87:197. |
| [14] | Mansfeld F,Tsai C H.Determination of coating deterioration with EIS.1.Basic relationships[J].Corrosion,1991,47:958. |
| [15] | Sekine I,Sakuguchi K,Yuasa M.Estimation and prediction of degradation of coating films by frequency at maximum phase angle[J].J.Coat.Technol.,1992,64:45. |
| [16] | Zuo Y,Pang R,Li W,et al.The evaluation of coating performance by the variations of phase angles in middle and high frequency domains of EIS[J].Corros.Sci.,2008,50:3322. |
| [17] | Hinderliter B R,Croll S G.Simulation of transient electrochemical impedance spectroscopy due to water uptake or oxide growth[J].Eiectrochim.Acta,2009,54:5344. |
| [18] | Hu J M,Zhang J T,Zhang J Q,et al.Corrosion electrochemical characteristics of red iron oxide pigmented epoxy coatings on aluminum alloys[J].Corros.Sci.,2005,47:2607. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%