对缺碳硬质合金采用渗碳处理制备梯度硬质合金,利用显微组织分析和维氏硬度测试等方法,研究渗碳工艺对梯度硬质合金的梯度结构和硬度的影响.结果表明:渗碳处理后随着渗碳时间延长,梯度层厚度增大,长时间渗碳还会出现梯度结构消失现象;渗碳时表面层WC晶粒长大,且渗碳时间越长晶粒长大越严重;渗碳后梯度硬质合金的表面硬度明显提高;渗碳后合金的表面硬度明显高于烧结态合金的表面硬度;随着渗碳时间的延长,合金表面硬度先增大后减小;合金的硬度在截面上沿梯度方向呈连续梯度变化,合金表面层因WC含量较高、钴含量较低而具有较高的硬度,中间层因钴含量较高、WC含量较低,其硬度较低.
参考文献
| [1] | (A)KERMAN J;FISCHER U K R;HARTZELL E T .Cemented carbide body with extra tough behavior[P].US 5453241,1995-09-26. |
| [2] | DROUGGE L .Tool of cemented carbide for cutting,punching or nibbling[P].US 5235879,1993-08-17. |
| [3] | FISCHER U K R;HARTZELL E T(A)KERMAN J .Cemented carbide with a binder phase gradient and method of making the same[P].US 4820482,1989-04-11. |
| [4] | Walter Lengauer;Klaus Dreyer .Functionally graded hardmetals[J].Journal of Alloys and Compounds: An Interdisciplinary Journal of Materials Science and Solid-state Chemistry and Physics,2002(1/2):194-212. |
| [5] | 羊建高,王海兵,刘咏,张林秋,李芳,龙郑易.碳含量对矿用硬质合金梯度结构形成的影响[J].中国有色金属学报,2004(03):424-428. |
| [6] | 张立;陈述;熊湘君;黄伯云 张传福 .双相结构功能梯度WC-Co合金的微观组织结构与小负荷维氏硬度[J].中国有色金属学报,2005,15(08):1194-1199. |
| [7] | 肖逸锋,贺跃辉,丰平,谢宏,张丽娟,黄自谦,黄伯云.碳含量对缺碳硬质合金组织和性能的影响[J].中国有色金属学报,2007(01):39-44. |
| [8] | 龙郑易,刘咏,贺跃辉,肖逸锋,周永贵,李芳.渗碳时间对梯度硬质合金显微组织和抗弯强度的影响[J].中国有色金属学报,2007(02):326-330. |
| [9] | Yong Liu;Haibing Wang;Zhengyi Long;Peter K. Liaw;Jiangao Yang;Baiyun Huang .Microstructural evolution and mechanical behaviors of graded cemented carbides[J].Materials Science & Engineering, A. Structural Materials: Properties, Misrostructure and Processing,2006(1/2):346-354. |
| [10] | LIU Yong;WANG Hai-bing;YANG Jian-gao;HUANG Bai-yun LONG Zheng-yi .Formation mechanism of cobalt gradient structure in WC-Co hard alloy[J].Journal of Materials Science Letters,2004,39:4397-4399. |
| [11] | UPADHYAYA A;SARATHY D;WAGNER G .Advances in alloy design aspects of cemented carbides[J].Materials & Design,2001,22(06):511-517. |
| [12] | MILMAN Y V;CHUGUNOVA S;GONCHBARUCK V;LUYCKX S NORTHROP I T .Low and high temperature hardness of WC-6wt%Co alloys[J].Inter J Refract Met Hard Mater,1997,15(1-3):97-101. |
| [13] | MILMAN Y V;LUYCKX S;NORTHROP I T .Influence of temperature,grain size and cobalt content on the hardness of WC-Co alloy[J].Inter J Refract Met Hard Mater,1999,17(1-3):39-44. |
| [14] | C. Larsson;M. Oden .Hardness profile measurements in functionally graded WC-Co composites[J].Materials Science & Engineering, A. Structural Materials: Properties, Misrostructure and Processing,2004(1/2):141-149. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%