将考虑湿热效应的经典层合板理论引入有限元方法中,通过精确考察单层板等效参数衰减、追踪初始破坏后的卸载以及对最终破坏进行判定,在精确预测湿热环境对复合材料性能影响的同时追踪了损伤演化过程.通过建立湿-热-力耦合下复合材料宏观性能的定量表达式,发展湿-热-力耦合环境下复合材料性能演化表征与预测方法,实现在有限元分析中考虑湿热效应的影响.对3种不同铺层方式复合材料层合板进行湿热环境试验研究,并利用本文中分析方法进行损伤模拟,分析结果与实验结果符合得较好.
By means of the introduction of the classic laminate theory with considering hygrothermal effect into the finite element method,the mechanical properties of composite in hygrothermal environment were accurately forecasted and the damage evolution was tracked through careful consideration of equivalent lamina parameters reduction and unloading after initial damage and estimation of final damage.The tensile and compressive strengths of three different lay-up composite laminates in hygrothermal environment were studied.There is good agreement between experiment and simulation results.
参考文献
| [1] | 杜善义.先进复合材料与航空航天[J].复合材料学报,2007,24(1):1-12.Du Shanyi.Advanced composite materials and aerospace engineering[J].Acta Materiae Compositae Sinica,2007,24(1):1-12. |
| [2] | Hu Huiwen,Sun C T.The characterization of physical aging in polymeric composites[J].Composites.Science and Technology,2000,60(14):2693-2698. |
| [3] | Jedidia J,Jacqueminb F,Vautrin A.Accelerated hygrothermal cyclical tests for carbon/epoxy laminates[J].Composites Part A,2006,37(4):636-645. |
| [4] | Earl J S,Shenoi R A.Hygrothermal ageing effects on FRP laminate and structural foam materials[J].Composites Part A,2004,35(11):1237-1247. |
| [5] | Thomas S G.On the use of accelerated test methods for characterization of advanced composite materials,NASA/TP-2003-212407[R].USA:NASA. |
| [6] | Marco G,Jerome M,Frédéric J,Alain V.On the nonlinear deformations of thin unsymmetric 0/90 composite plates under hygrothermal loads[J].Composites Part A,2006,37(4):624-629. |
| [7] | Onur S.Analysis of multi-layered composite cylinders under hygrothermal loading[J].Composites Part A,2005,36(7):923-933. |
| [8] | Michael W Hyer.Stress of fiber-reinforced composite materials[M].USA:WCB/McGraw-Hill,1998:239-307. |
| [9] | 郑锡涛,李野,刘海燕,郭稳学.湿热谱老化对复合材料层压板强度的影响[J].航空学报,1998,19(4):462-465.Zheng Xitao,Li Ye,Liu Haiyan,Guo Wenxue.Effects of wet/hot spectrum aging on strength of composite laminates[J].Acta Aeronautica et Astronautica Sinica,1998,19(4):462-465. |
| [10] | Zinoviev P,Grigoriev S V,Labedeva O V,Tairova L R.Strength of muti-layered composites under plane stress state[J].Composites Science and Technology,1998,58(7):1209-1224. |
| [11] | Solden P D,Kaddour A S,Hinton M J.Recommendations for designers and researchers resulting from the world-wide failure exercise[J].Composites Science and Technology,2004,64(3/4):589-604. |
| [12] | 燕瑛,韩凤宇,杨东升,刘兵山.缝合复合材料弹性性能的三维有限元细观分析与试验验证[J].航空学报,2004,25(3):267-269.Yan Ying,Han Fengyu,Yang Dongsheng,Liu Bingshan.Finite element micromechanical analysis and experimental confirmation of the elastic properties of stitched composite materials[J].Acta Aeronautica et Astronautica Sinica,2004,25(3):267-269. |
| [13] | 王立朋,燕瑛.混合机织复合材料低速冲击损伤有限元分析[J].航空学报,2007,28(4):121-124.Wang Lipeng,Yan Ying,Finite element analysis of low-velocity impact damage of mixed woven composites[J].Acta Aeronautica et Astronautica Sinica,2007,28(4):121-124. |
| [14] | Wang L P,Yah Y.Low-velocity impact damage analysis of composite laminates using self-adapting delamination element method[J].Chinese Journal of Aeronautics,2008,21(4):313-319. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%