采用正硅酸乙酯(TEOS)在酸性条件下水解制备了溶剂型无机硅酸锌底漆的固化剂——TEOS水解液,通过升高储存温度的方法研究了水解度、酸水pH对TEOS水解液储存稳定性的影响.结果表明,以pH=2.5的酸水为催化剂,水解得到水解度为80％的TEOS水解液具有良好的储存稳定性,其在常温下的储存期可达12个月,以此TEOS水解液制备的无机硅酸锌底漆具有表干快、附着力优良、耐蚀性好等特点.
参考文献
| [1] | Hoshyargar, F;Sherafati, SA;Hashemi, MM .A new study on binder performance and formulation modification of anti-corrosive primer based on ethyl silicate resin[J].Progress in Organic Coatings: An International Review Journal,2009(3):410-413. |
| [2] | van Vliet CH. .Reduction of zinc and volatile organic solvents in two-pack anticorrosive primers. a pilot study[J].Progress in Organic Coatings: An International Review Journal,1998(1/4):220-226. |
| [3] | Rubio F.;Oteo JL.;Rubio J. .A FT-IR study of the hydrolysis of tetraethylorthosilicate (TEOS).[J].Spectroscopy Letters,1998(1):199-219. |
| [4] | Marino IG;Lottici PP;Bersani D;Raschella R;Lorenzi A;Montenero A .Micro-Raman monitoring of solvent-free TEOS hydrolysis[J].Journal of Non-Crystalline Solids: A Journal Devoted to Oxide, Halide, Chalcogenide and Metallic Glasses, Amorphous Semiconductors, Non-Crystalline Films, Glass-Ceramics and Glassy Composites,2005(6/7):495-498. |
| [5] | 王喜贵,赵慧,张强,吴红英.正硅酸乙酯水解过程的研究进展[J].内蒙古石油化工,2001(03):17-19. |
| [6] | 温静卫,王同赛,叶爱玲.醇溶性无机富锌底漆固化程度的影响因素研究[J].中国涂料,2010(10):25-27. |
| [7] | Ghosh, S.K.;Waghoo, G.;Kalita, A.;Balgude, D.;Kumar, K.R. .Chloride-free biodegradable organic acid hydrolyzed zinc silicate coating[J].Progress in Organic Coatings: An International Review Journal,2012(1):70-75. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%