通过摩擦试验，研究了正压力、相对滑动速度以及润滑条件对井下防喷器胶筒与套管间摩擦因数的影响。结果表明：相同正压力下，无润滑剂和水润滑摩擦时，两者间的摩擦因数随着滑动速度的增加而增加，在油润滑时，滑动速度的增加有利于润滑膜的形成，使摩擦因数降低；在相同正压力和相对滑动速度下，油润滑摩擦因数均值最小，水润滑时次之，无润滑剂时最大；正压力的影响无规律性。
The influences of positive pressure, relative sliding rate and lubrication condition on friction coefficient between sealing rubber of downhole bop and casing pipe were studied by friction test. The results show that the friction coefficient increased with the sliding rate increasing at the same positive pressure without lubricant or water lubrication, but decreased in oil lubrication because the growth of sliding rate made contribution to the formation of lubricating film. At the same pressure and relative rate, the average friction coefficient in oil lubrication was the smallest, followed by that in water lubrication and the greatest was given without lubricant. The effect of positive pressure had no regularity.
参考文献
| [1] | 潘炳力,杜三明,高喜平,张春飞,张玉清,张永振.聚双环戊二烯在干摩擦和油润滑条件下的摩擦学性能[J].摩擦学学报,2009(06):565-571. |
| [2] | 何仁洋,张嗣伟,王德国,石油大学.干摩擦条件下天然橡胶/钢的磨损机理研究[J].摩擦学学报,2001(04):260-265. |
| [3] | 何仁洋,张嗣伟,王德国,李明远.边界润滑条件下天然橡胶-钢磨损机理的研究[J].摩擦学学报,2001(06):439-442. |
| [4] | 杨秀娟,闫相祯,贾善坡.封隔器胶筒大变形的粘-滑摩擦接触分析[J].机械强度,2006(02):229-234. |
| [5] | 白新理,杨开云,王文媛,赵新铭.不可压缩超弹性材料大变形接触分析[J].四川大学学报(工程科学版),2001(01):16-19. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%