采用实验研究和理论分析相结合的方法研究了体积分数为0.15～3％超低浓度甲烷在0.5％ Pd/Al2O3(质量分数)催化颗粒鼓泡流态化状态下的催化燃烧特性,根据其在密相区和稀相区的流动及反应特点,建立了低浓度甲烷催化燃烧反应模型,并在不同温度、进气甲烷浓度、床层高度等工况下进行了模型预测及与实验数据的对比分析.研究结果表明:考虑了稀相区中催化颗粒飞溅,模型计算数据与实验数据吻合较好,误差在5％以内;反应器出口无量纲甲烷浓度随着床层温度的升高、进气甲烷浓度的降低以及床层高度的升高而降低;通过与活塞流,全混流反应模型的对比分析,进一步验证了所建立的数学模型能够较好地反映超低浓度甲烷在鼓泡流态化状态下的催化燃烧特性.
参考文献
| [1] | Gosiewski K;Warmuzinski K .Effect of the mode of heat withdrawal on the asymmetry of temperature profiles in reverse-flow reactors. Catalytic combustion of methane as a test case[J].Chemical Engineering Science,2007(10):2679-2689. |
| [2] | Danilo Klvana;Jamal Chaouki;Christophe Guy;Jitka Kirchnerova;Massimiliano Zanoletti .Performance of Auto-Cyclic Reactor in Catalytic Combustion of Lean Fuel Mixtures[J].Industrial & Engineering Chemistry Research,2005(25):9676-9682. |
| [3] | 杨仲卿,张力,唐强,蒲舸.超低浓度煤层气在流化床中燃烧的实验和数值研究[J].工程热物理学报,2011(11):1979-1981. |
| [4] | You, CF;Xu, XC .Utilization of ventilation air methane as a supplementary fuel at a circulating fluidized bed combustion boiler[J].Environmental Science & Technology,2008(7):2590-2593. |
| [5] | Mario Iamarino;Paola Ammendola;Riccardo Chirone;Raffaele Pirone;Giovanna Ruoppolo;Gennaro Russo .Nonpremixed Catalytic Combustion of Methane in a Fluidized Bed Reactor[J].Industrial & Engineering Chemistry Research,2006(3):1009-1013. |
| [6] | Zukowski W. .The role of two-stage combustion in the development of oscillations during fluidized bed combustion of gases[J].Fuel,2000(14):1757-1765. |
| [7] | R.Sotudeh-Gharebagh;J.Chaouki;P.Sauriol .An experimental study of non-premixed combustion in a turbulent fluidized-bed reactor[J].Fuel Processing Technology,2007(9):847-858. |
| [8] | 张力,杨仲卿,唐强.流化床燃烧超低浓度煤层气的轴向气体分布[J].工程热物理学报,2012(02):248-250. |
| [9] | Jean-Philippe Laviolette;Gregory S. Patience;Concetta La Marca;Jamal Chaouki .Gas-phase propane combustion in the freeboard of a fluidized bed[J].Fuel,2013(Sep.):316-323. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%