P110钢在CO2／H2S环境中的适用性研究

腐蚀学报（英文）, 2012, 24(1): 32-36.

P110钢在CO2／H2S环境中的适用性研究

韩燕 ^1, , 赵雪会 ^2, , 白真权 ^3, , 尹成先 ^4,

1.中国石油集团石油管工程技术研究院,西安,710065

2.中国石油集团石油管工程技术研究院,西安,710065

3.中国石油集团石油管工程技术研究院,西安,710065

4.中国石油集团石油管工程技术研究院,西安,710065

关键词：腐蚀评价 , 氢损伤 , 应力腐蚀 , CO2/H2S腐蚀 , 腐蚀速率

Applicability of P110 Steel in CO2/H2S Containing Environments

Keywords： corrosion evaluation , hydrogen damage , stress corrosion , CO2/H2S corrosion , corrosion rate

采用高温高压实验设备辅以失重法，研究了CO2／H2S腐蚀环境中P110钢的腐蚀性能，用SEM、EDS和XRD等分析了腐蚀产物．分别用电化学充氢及NACE TM0177A法对P110钢进行耐氢损伤试验．结果表明，虽然P110钢在试验环境中的均匀腐蚀速率很小，未发生点蚀，但随着充氢量的增加，强度、伸长率及断面收缩率均降低．充氢量达到一定程度时，材料由韧性断裂转变为脆性断裂．P110钢未通过NACETM0177标准A法对应力腐蚀开裂性能的检测．因此，当井下环境中含H2S时，P110钢的使用安全性有待进一步提高．

CO2/H2S induced corrosion behavior of P110 steel was investigated in high temperature and high pressure autoclave, and corrosion rate was measured by mass loss method. The corrosion product scale was analyzed by using scanning electron microscope（SEM）, energy dispersive X-ray spectrometer （EDS） and X-ray diffractometers （XRD）. And the resistance to hydrogen damage of P110 steel was tested by electrochemical hydrogen charging and NACE TM0177 A method, respectively. The results showed that the uniform corrosion rates of P110 steel are quite low, and there is no localized corrosion in CO2/H2S environments. But with the increase of the amount of hydrogen charging, the tensile strength, elongation and area reduction rate decrease for P110 steel. When charging enough, the fracture mode According to NACE TM0177 Standard A exists, the service safty of P110 steel needs was changed from ductile fracture to brittle fracture. method, the samples fail. Therefore, when the H2S to be further improved.

参考文献

[1]	Lyer R N, Takeuchi I. Hydrogen sulfide effect on hydrogen entry into iron [J]. Corrosion, 1990, 46(7): 415.
[2]	戴金星,胡见义,贾承造等.科学安全勘探开发高含硫化氢天然气田的建议[J].石油勘探与开发,2004,3l(2):1.
[3]	Nesic S, Lunde L. Carbon dioxide corrosion of carbon steel in two-phase flow [J]. Corrosion, 1994, 50(9): 717.
[4]	朱世东,白真权,林冠发等.高Cl-条件下H2S分压对P110钢腐蚀速率的影响[J].腐蚀与防护,2009,30(5):293.
[5]	白真权,李鹤林,刘道新等.模拟油田CO2/H2S环境中N80钢的腐蚀及影响因素研究[J].材料保护,2003,36(4):32.
[6]	周计明.油管钢在含CO2/H2S高温高压水介质的腐蚀行为及防护技术的作用[D].西安:西北工业大学硕士学位论文,2002,21.
[7]	Srinivasan S, Kane R D. Experimental simulation of multiphase CO2/H2S system [J]. Corrosion, 1999 (14): 1168.
[8]	马丽萍,王永清,赵素惠.CO2和H2S在井下环境中共存时对油管钢的腐蚀[J].西部探矿工程,2006,(11):50.
[9]	苗健,白真权,严文等.模拟油田CO2/H2S环境P110钢的腐蚀行为研究[J].石油矿场机械,2004,33(6):53.

上一张下一张

计量

下载量()
访问量()

作者相关

文章评分

您的评分：
1

0%
2

0%
3

0%
4

0%
5

0%

材料期刊网