在对黄铁矿与铝酸钠溶液反应热力学分析的基础上,利用接触角、X 射线衍射、红外光谱和 SEM-EDS等分析手段研究溶出温度和铝酸钠溶液组成对黄铁矿反应行为的影响,并探讨黄铁矿的分解过程.结果表明,黄铁矿的反应速度随溶液温度及游离碱浓度的升高而加快,最终产物主要为 Fe2O3、S2?和 SO42?;拜耳法溶出条件下,反应1 h黄铁矿中硫溶出率高达90%;反应初始阶段黄铁矿表面的Fe2+优先与溶液中的OH?结合生成铁羟基化合物从表面脱落,导致富硫层的形成,随着反应的进行,硫最终以S2?和SO42?形式进入溶液.
@@@@Based on the thermodynamic analysis of the reaction between pyrite and sodium aluminate solution, the effects of digestion temperature and composition of the sodium aluminate solution on the reaction behavior of pyrite were investigated by the analysis of contact angle, X-ray diffraction, infrared spectrum and scanning electron microscope?energy dispersive spectrum. The decomposition process of pyrite was also discussed. The results show that the reaction rate of pyrite increases with the increase of the temperature and the free caustics concentration in aluninate solution to produce Fe2O3, S2? and SO42? as the main final products. The sulfur dissolution percentage reaches above 90% after reaction of 1 h under the Bayer process. The iron-hydroxyl complexes are generated firstly by the reaction of OH? of sodium aluminate solution and Fe2+of the pyrite surface, then the complexes detach from the surface of pyrite, which leads to a layer of sulfur-rich compounds. Finally, the sulfur enters into the solution in the form of S2?and SO42?.
参考文献
| [1] | Jianguo Yin;Wentang Xia;Mingrong Han .RESOURCE UTILIZATION OF HIGH-SULFUR BAUXITE OF LOW-MEDIAN GRADE IN CHONGQING CHINA[J].Light metals,2011(2011):19-22. |
| [2] | International Aluminum Institute .The aluminum industry's sustainable development report[R].London:The Swallow House Group of Companies,2002. |
| [3] | ABIKENOVA G K;KOVAZLENKO V A;AMBARNIKOVA G A;IBRAGIMOV A T .Investigation of the effect and behavior of sulfur compounds on the technological cycle of alumina production[J].Metallurgy of Nonferrous Metals,2008,49(02):91-96. |
| [4] | 吕国志,张廷安,鲍丽,豆志河,赵爱春,曲海翠,倪培远.高硫铝土矿的焙烧预处理及焙烧矿的溶出性能[J].中国有色金属学报,2009(09):1684-1689. |
| [5] | HU Xiao-lian;CHEN Wen-mi;XIE Qiao-ling .Sulfur phase and sulfur removal in high sulfur-congtaining bauxite[J].Transactions of Nonferrous Metals Society of China,2011,21(07):1641-1647. |
| [6] | PADILLA R;VEGA D;RUIZ M C .Pressure leaching of sulfides chalcopyrite in sulfuric acid-oxygen media[J].HYDROMETALLURGY,2007,85(12):80-88. |
| [7] | 胡小莲,陈文汨.采用湿式氧化法脱除铝酸钠溶液中硫的研究[J].中南大学学报（自然科学版）,2011(10):2911-2916. |
| [8] | 何强.粗、精液降温过滤降低高硫矿拜耳法产品中铁含量的研究[J].轻金属,2010(08):12-16. |
| [9] | 宋超,彭志宏,魏欣欣,齐天贵.黄铁矿在拜耳法溶出过程中的反应行为研究[J].有色金属科学与工程,2011(05):1-5. |
| [10] | 彭容秋.重金属冶金学[M].长沙:中南大学出版社,2009:277-279. |
| [11] | 陈万坤;彭关才.一水硬铝石型铝土矿的强化溶出技术[M].北京:冶金工业出版社,1997:112-116. |
| [12] | 杨显万;何葛平.高温水溶液热力学数据计算手册[M].北京:冶金工业出版社,1985:412-414. |
| [13] | 傅崇说.有色冶金原理[M].北京:冶金工业出版社,1993:154-158. |
| [14] | 刘桂华,李小斌,李永芳,彭志宏.复杂无机化合物组成与热力学数据间的线性关系及其初步应用[J].科学通报,2000(13):1386-1392. |
| [15] | Caldeira, CL;Ciminelli, VST;Osseo-Asare, K .The role of carbonate ions in pyrite oxidation in aqueous systems[J].Geochimica et Cosmochimica Acta: Journal of the Geochemical Society and the Meteoritical Society,2010(6):1777-1789. |
| [16] | C. L. Caldeira;V. S. T. Ciminelli;A. Dias .Pyrite oxidation in alkaline solutions: nature of the product layer[J].International Journal of Mineral Processing,2003(1/4):373-386. |
| [17] | AHLBERG E;FORSSBERG K S R;WANG X .The surface oxidation of pyrite in alkaline solution[J].Journal of Applied Electrochemistry,1990,20(06):1033-1039. |
| [18] | Schaufuss AG.;Kartio I.;Laajalehto K.;Bancroft GM. Szargan R.;Nesbitt HW. .Reactivity of surface chemical states on fractured pyrite[J].Surface Science: A Journal Devoted to the Physics and Chemistry of Interfaces,1998(3):321-328. |
| [19] | 赵伦山;张本仁.地球化学[M].北京:地质出版社,1988:78-81. |
| [20] | 孙水裕.硫化矿-溶液界面电子转移的前线分子轨道理论讨论[J].北京矿冶研究总院学报,1994(01):34. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%