添加了惰性元素的锌基合金镀层的耐蚀性比纯锌镀层更高,是钢铁材料常用的耐蚀表面保护层.评述了锌基合金镀层、组分调制锌基多层镀层的性能特点及研究现状,并比较了各类镀层的耐蚀性及实用性.
A review was provided of the properties and current status of zinc alloy coatings and zinc- based compositionally modulated multilayer coatings. The corrosion resistance and applicability of various electroplated Zn-based coatings were comparatively analyzed.
参考文献
| [1] | Sard R .Advances in functional zinc and zinc alloy coatings[J].Plating and Surface Finishing,1987,74(22):30-34. |
| [2] | 张兴文,费敬银,周国华.超高强度钢环保型电镀锌镍合金层的耐蚀性研究[J].材料保护,2008(06):60-64. |
| [3] | 惠百平,费敬银,辛文利,刘江宏,王卫康.Zn-Ni合金电沉积过程中的渗氢行为[J].电镀与精饰,2006(02):10-13,41. |
| [4] | 王卫康,费敬银.电沉积Zn-Fe合金的渗氢行为研究[J].电镀与环保,2007(04):14-17. |
| [5] | Ramanauskas R;Quintana P;Maldonado L .Corrosion resistance and microstructure of electrodeposited Zn and Zn alloy coatings[J].Surface and Coatings Technology,1997,92(01):16-21. |
| [6] | Short N R;Zhou S;Dennis J K .Electrochemical studies on the corrosion of a range of zinc alloy coated steel in alkaline solutions[J].Surface and Coatings Technology,1996,79(1-3):218-224. |
| [7] | Wilcox G D;Gabe D R .Electrodeposited zinc alloy coatings[J].Corrosion Science,1993,35(5-8):1251-1258. |
| [8] | Bates J A .Comparison of alkaline Zn-Ni and acid Zn-Ni as a replacement coating for cadmium[J].Surface Finishing,1994,81(04):36-40. |
| [9] | Wright D A .Zn-Ni electroplate as a replacement for cadmium on high-strength steels[J].Plating and Surface Finishing,1994,81(07):18-21. |
| [10] | Vitkova S;Ivanova V;Raichevsky G .E]ectrodeposition of low tin content zinc-tin alloys[J].Surface and Coatings Technology,1996,82(03):226-231. |
| [11] | Andrew P;Capper G .Electrodeposition of zinc-tin alloy from deep eutectic solvents based on chlorine chloride[J].Journal of Electroanalytical Chemistry,2007,559(02):228-294. |
| [12] | J. D. Jensen;G. W. Critchlow;D. R. Gabe .A study on zinc-iron alloy electrodeposition from s chloride-electrolyte[J].Transactions of the Institute of Metal Finishing,1998(5):187-191. |
| [13] | E. Beltowska-Lehman;P. Ozga;Z. Swiatek;C. Lupi .Influence of structural factor on corrosion rate of functional Zn-Ni coatings[J].Crystal engineering,2002(3/4):335-345. |
| [14] | Shears A P .Zinc-cobalt deposits from an acid chloride electrolyte[J].Trans lnst Met Fin,1989,67(01):67-69. |
| [15] | 安茂忠.锌-镍合金钝化膜的组成和结构对耐蚀性的影响[J].材料保护,1994(01):11. |
| [16] | Pech-Canul M A;Ramananskas R .An electrechemical investigation of passive layers formed on electredeposited Zn and Zn alloy coatings in alkaline solutions[J].Electrochimica Acta,1997,42(02):255-260. |
| [17] | Diaz S L;Mattos 0 R;Bareia 0 E .Zn-Fe anomalous electredeposition:stationeries and local pH measurement[J].Electrochimica Acta,2002,47(25):4091-4100. |
| [18] | Gomez E.;Valles E. .ELECTRODEPOSITION OF ZINC PLUS COBALT ALLOYS - INITIATIONS AND DEVELOPMENT OF ANOMALOUS CO-DEPOSITION[J].Journal of Electroanalytical Chemistry: An International Journal Devoted to All Aspects of Electrode Kinetics, Interfacial Structure, Properties of Electrolytes, Colloid and Biological Electrochemistry,1997(1/2):157-163. |
| [19] | Abibsi A;Dennis J K;Short N R .The effect of plating variables on zinc-nickel alloy electrodeposition[J].Transactions of the Institute of Metal Finishing,1991,69(04):145-148. |
| [20] | Brenner A .Electredeposition of Alloys[J].Journal of the Electrochemical Society,1964,111(02):34-35. |
| [21] | David Crotty .Zinc Alloy Plating for the Automotive Industry[J].Metal finishing,1996(9):54,56-58-0. |
| [22] | Roev V G;Gudin N V .New aspects of zinc-nickel alloy codepozition[J].Transactions of the Institute of Metal Finishing,1996,74(05):153-156. |
| [23] | Fratesi R;Roventi G .Corrosion resistance of Zn-Ni alloy coatings in industrial production[J].Surface and Coatings Technology,1996,82(1,2):158-164. |
| [24] | Gary W L;Klaus R R;Tetuhiro J A .Zinc-alloy electredeposits for improved corrosion protection[J].Plating and Surface Finishing,1991,78(03):74-79. |
| [25] | Sngiyama M;Urakawa T;Adaniya T .Electredepositioa of zinc manganese on steel strip[J].Plating and Surface Finishing,1987,74(11):77-82. |
| [26] | C. Muller;M. Sarret;T. Andreu .ZnMn alloys obtained using pulse, reverse and superimposed current modulations[J].Electrochimica Acta,2003(17):2397-2404. |
| [27] | DUAN You-gou,FU Wei-chang,PENG Qing-jing.Electroplating Zn-Al Alloy Technology[J].武汉理工大学学报(材料科学版)英,2002(03):54-55. |
| [28] | Tz. Boiadjieva;D. Kovacheva;K. Petrov;S. Hardcastle;M. Monev .Effect of anodic treatment on the composition and structure of electrodeposited Zn-Cr alloy coatings[J].Corrosion Science,2004(3):681-695. |
| [29] | Yu Shengxue;Chen Ling .Preparation Technology and Performances of Zn-Cr Coating on Sintered NdFeB Permanent Magnet[J].Journal of Rare Earths,2006(2):223-226. |
| [30] | Mary M. Younan .Electrodeposition of ternary zinc-nickel-cobalt alloys from an acidic chloride bath[J].Metal finishing,2000(10):38-42. |
| [31] | Bajat JB.;Miskovic-Stankovic VB.;Kacarevic-Popovic Z. .The influence of steel surface modification by electrodeposited Zn-Fe alloys on the protective behaviour of an epoxy coating [Review][J].Progress in Organic Coatings: An International Review Journal,2003(1):49-54. |
| [32] | Ordine A P;Diza S L;Margait I C .Zn-Fe and Zn-Ni alloy deposits modified by P incorporation:anticorroaion properties[J].Electrochimica Acta,2000,49(17,18):2815-2823. |
| [33] | Yang ZN;Zhang Z;Zhang JQ .Electrodeposition of decorative and protective Zn-Fe coating onto low-carbon steel substrate[J].Surface & Coatings Technology,2006(16/17):4810-4815. |
| [34] | Lan CJ;Liu WY;Ke ST;Chin TS .Potassium salt based alkaline bath for deposition of Zn-Fe alloys[J].Surface & Coatings Technology,2006(6):3103-3108. |
| [35] | 曾祥德.影响氯化物电镀锌铁合金工艺的稳定因素[J].电镀与环保,2001(06):10-11. |
| [36] | Barbosa LL;Carlos IA .Development of a novel alkaline zinc-iron plating bath containing sorbitol and the chemical, physical and morphological characterization of the Zn-Fe films[J].Surface & Coatings Technology,2006(3/4):1695-1703. |
| [37] | Higashi K;Fukushima M;Urakawa T .Mechanism of the electrodeposition of zinc alloys containing a small amount of cobalt[J].Journal of the Electrochemical Society,1981,128(10):2081-2085. |
| [38] | Boshkov N.;Petrov K.;Vitkova S.;Nemska S.;Raichevsky G. .Composition of the corrosion products of galvanic alloys Zn-Co and their influence on the protective ability[J].Surface & Coatings Technology,2002(2/3):171-178. |
| [39] | A Stankeviciute;K. Leinartas;G. Bikulcius;D. Virbalyte;A. Sudavicius;E. Juzeliunas .Deposition of Zn-Co by constant and pulsed current[J].Journal of Applied Electrochemistry,1998(1):89-95. |
| [40] | 安茂忠.锌钴合金镀层结构与耐蚀性研究[J].材料保护,1998(04):5. |
| [41] | J. B. Bajat;V. B. Miskovic-Stankovic;M. D. Maksimovic;D. M. Drazic;S. Zec .Electrochemical deposition and characterization of Zn-Co alloys and corrosion protection by electrodeposited epoxy coating on Zn-Co alloy[J].Electrochimica Acta,2002(25):4101-4112. |
| [42] | V. Narasimhamurthy;B. S. Sheshadri .Electrodeposition of zinc-cobalt alloy from an alkaline sulfate bath containing triethanolamine and gelatin[J].Metal finishing,1998(4):24-27. |
| [43] | Po-Yu Chen;I-Wen Sun .Electrodeposition of cobalt and zinc-cobalt alloys from a lewis acidic zinc chloride-1-ethyl-3-methylimidazolium chloride molten salt[J].Electrochimica Acta,2001(8):1169-1177. |
| [44] | Gomez E;Alcobe X;Valles E .Characterization of Zn-Co alloy phase obtained by electrodeposition[J].Journal of Electroanalytical Chemistry,2001,505(1,2):54-61. |
| [45] | Bahrololoom M E;Gabe D R;Wilcox G D .Development of a bath for eleetrodeposition of zinc-cobalt compositionally modulated alloy multilayered coatings[J].Journal of Electrothem Soe,2003,150(03):144-151. |
| [46] | Fei J Y;Wilcox G D .Electrodepositian of Zn-Co alloys with pulse containing reveme current[J].Electrochimica Acta,2005,50(13):2693-2698. |
| [47] | Koehler J S .Attempt to design a strong solid[J].Physical Review B:Condensed Matter,1970,2(02):547-551. |
| [48] | Ebrahimi F;Liscano A J .Mierostructure/mechanieal properties relationship in eleetrodeposited Ni/Cu nanolaminates[J].Materials Science and Engineering,2001,301(01):23-34. |
| [49] | Oliveira J B;Sard M A;Machndo J M .Determination of diffusion in electrodeposited Cu-Ni compositionally-modulated multilayers based on magnetic measurements[J].Journal of Alloys and Compounds,1996,239(01):41-45. |
| [50] | Lassri H;Ouahmane H .Ferromagnetic resonance studies of electrodeposited Ni/Cu muhilayers[J].Thin Solid Films,2001,389(1,2):245-249. |
| [51] | Yamads A;Houga T;Ueda Y .Magnetism and magnetoresistance of Co/Cu multilayer film produced by pulse control electrodepesition method[J].Journal of magnetism and magnetic materials,2002,239(1-3):272-275. |
| [52] | Despic A R;Trisovic T L .Transition layer thickness in micrelarainar deposits[J].Journal of Applied Electrochemistry,1993,23(06):662-668. |
| [53] | Hayashi Y;Kashiwabara S;Yoka Y .Preparation and characterization of eleetredeposited metallic multilayers[J].Physica B,1997,239(1,2):35-40. |
| [54] | Gabe D R .Protective layered electrodeposits[J].Electrochimica Acta,1994,39(8,9):1115-1121. |
| [55] | M. R. Kalantary;G. D. Wilcox;D. R. Gabe .Alternate layers of zinc and nickel electrodeposited to protect steel[J].British Corrosion Journal,1998(3):197-201. |
| [56] | Chawa G;Wilcox G D;Gabe D R .Compositionally modulated zinc alloy coatings for corrosion protection[J].Transactions of the Institute of Metal Finishing,1998,76(03):117-120. |
| [57] | Kirilova I;Ivanov I;Rashkov S .Anodic behavionr of compositionally modulated Zn-Co multilayer electrodeposited from single and dual hath[J].Journal of Applied Electrochemistry,1998,28(12):1359-1363. |
| [58] | Fei JY;Wilcox GD .Electrodeposition of zinc-nickel compositionally modulated multilayer coatings and their corrosion behaviours[J].Surface & Coatings Technology,2006(11):3533-3539. |
| [59] | FEI Jing-yin;LIANG Guo-zheng;XIN Wen-li .Surface Modification With Zinc and Zn-Ni Alloy Compositionally Modulated Multilayer Coatings[J].Journal of iron and steel research,2006(4):61-67. |
| [60] | FEI Jingyin,LIANG Guozheng,XIN Wenli,LIU Jianghong.Corrosion Performance of Zinc and Zinc-cobalt Alloy Compositionally Modulated Multilayer (CMM) Coatings[J].武汉理工大学学报(材料科学版)英,2006(04):40-44. |
| [61] | Wilcox G D.Surface modification with compesitionally modulated multilayer coatings[J].Journal of Corrosion Science and Engineering,2003(06):126-135. |
上一张
下一张
上一张
下一张
计量
- 下载量()
- 访问量()
文章评分
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%