采用长春黄金研究院自制的沉铜混凝剂CCG001与目前常用的混凝剂PAC、PFS、PFC、FAFC、Al2（ SO4）3、FeSO4进行试验比较，得出CCG001在混凝沉铜上具有相对优势。以CCG001和APAM为混凝剂，对某黄金矿山尾矿库氰渣淋溶液进行了一系列混凝沉铜试验。在单因素试验基础上，以pH值和混凝剂投加量为影响因素，以铜离子和COD去除率为响应值，采用BBD试验设计和响应面法建立了铜离子和COD去除率的响应面方程。通过对数学模型进行求解得知，在pH值为9．99、CCG001用量为205．22 mg/L、APAM投加量为3．32 mg/L的条件下，铜离子和COD去除率可同时达到最大值，分别为96．95％和83．24％。验证试验结果表明：响应面法的预测值与试验值吻合较好，建立的模型具有较高的可信度；响应面法是一种有效地优化废水混凝条件的方法。
This paper adopts the self-made coagulant CCG 001 by Changchun Gold Research Institute to compara-tively experiment with the coagulants of PAC,PFS,PFC,FAFC,Al2(SO4)3 and FeSO4,CCG001 has better perform-ance .A coagulation-flocculation process was used to treat the leaching liquor of cyanidation slag in tailings reservoir of a certain gold mine with CCG001 as coagulant and anionic polyacrylamide ( APAM) as flocculant.Based on the result of single factor experiments ,response surface formula of copper ion and COD removal rate is established using BBD design and response surface methodology with pH value and dosage of coagulants as influencing factor and COD re -moval rate as response value .The optimal conditions obtained from mathematical calculation were pH value of 9.99, CCG001 dosage of 205 .22 mg/L, and APAM dosage of 3 .32 mg/L respectively .Under the optimal conditions , the maximal copper ion removal rate (96.96%) and the maximal COD removal rate (83.24%) could be achieved.The RSM was demonstrated as an appropriate approach for the optimization of the coagulation-flocculation process with consistent predicted value and experimental value ,and persvasive establishment of models .
参考文献
| [1] | Removal Of Copper(Ⅱ) From Aqueous Phase By Purolite C100-mb Cation Exchange Resin In Fixed Bed Columns: Modeling[J].Journal of hazardous materials,2009(2/3):737-746. |
| [2] | Sud, D;Mahajan, G;Kaur, MP .Agricultural waste material as potential adsorbent for sequestering heavy metal ions from aqueous solutions - A review[J].Bioresource Technology,2008(14):6017-6027. |
| [3] | M. Ahmadi;F. Vahabzadeh;B. Bonakdarpour;E. Mofarrah;M. Mehranian .Application of the central composite design and response surface methodology to the advanced treatment of olive oil processing wastewater using Fenton's peroxidation[J].Journal of hazardous materials,2005(1/3):187-195. |
| [4] | Barbara Bianco;Ida De Michelis;Francesco Veglio .Fenton treatment of complex industrial wastewater: Optimization of process conditions by surface response method[J].Journal of hazardous materials,2011(2/3):1733-1738. |
| [5] | Srimanta Ray;Jerald A.Lalman;Nihar Biswas .Using the Box-Benkhen technique to statistically model phenol photocatalytic degradation by titanium dioxide nanoparticles[J].Chemical engineering journal,2009(1):15-24. |
| [6] | Yang, ZH;Huang, J;Zeng, GM;Ruan, M;Zhou, CS;Li, L;Rong, ZG .Optimization of flocculation conditions for kaolin suspension using the composite flocculant of MBFGA1 and PAC by response surface methodology[J].Bioresource Technology: Biomass, Bioenergy, Biowastes, Conversion Technologies, Biotransformations, Production Technologies,2009(18):4233-4239. |
| [7] | Optimization for decolorization of azo dye acid green 20 by ultrasound and H_2O_2 using response surface methodology[J].Journal of hazardous materials,2009(2/3):1388. |
| [8] | Xudong Li;Rong Jia;Pingsheng Li .Response surface analysis for enzymatic decolorization of Congo red by manganese peroxidase[J].Journal of molecular catalysis, B. Enzymatic,2009(1):1-6. |
| [9] | Karacan F;Ozden U;Karacan S .Optimization of manufacturing conditions for activated carbon from Turkish lignite by chemical activation using response surface methodology[J].Applied thermal engineering: Design, processes, equipment, economics,2007(7):1212-1218. |
| [10] | 王玉峰,陈克复,莫立焕,周志明.响应面法优化絮凝处理造纸法烟草薄片废水[J].中华纸业,2013(02):34-39. |
| [11] | Srimanta Ray;Jerald A.Lalman;Nihar Biswas .Using the Box-Benkhen technique to statistically model phenol photocatalytic degradation by titanium dioxide nanoparticles[J].Chemical engineering journal,2009(1):15-24. |
| [12] | Bahadir K. Koerbahti;Muhammad A. Rauf .Determination Of Optimum Operating Conditions Of Carmine Decoloration By Uv/h_2o_2 Using Response Surface Methodology[J].Journal of hazardous materials,2009(1):281-286. |
| [13] | Olmez T .The optimization of Cr (Ⅵ) reduction and removal by electrocoagulation using response surface methodology[J].Journal of Hazardous Materials,2009,162(2-3):1371-1378. |
| [14] | 赵选民.试验设计方法[M].北京:科学出版社,2006:221-228. |
| [15] | Draginja P;Ljiljana R;Svetlana T et al.Evaluation of solubility of pumpin seed globulins by response surface method[J].Journal of Food Engineering,2008,84:591-594. |
| [16] | Ahmada A L;Wong S S;Teng T T et al.Improvement of ahum and PACl coagulation by polycrylamides (PAMs) for the treatment of pulp and paper mill wastewater[J].Chemical Engineering Journal,2008,137:510-517. |
| [17] | S.S. Wong;T.T. Teng;A.L. Ahmad;A. Zuhairi;G. Najafpour .Treatment of pulp and paper mill wastewater by polyacrylamide (PAM) in polymer induced flocculation[J].Journal of hazardous materials,2006(1/3):378-388. |
| [18] | Wang JP;Chen YZ;Ge XW;Yu HQ .Optimization of coagulation-flocculation process for a paper-recycling wastewater treatment using response surface methodology[J].Colloids and Surfaces, A. Physicochemical and Engineering Aspects,2007(1/3):204-210. |
| [19] | Jang-Hyuk Ahn;Young-Pil Kim;Yu-Mi Lee;Eun-Mi Seo;Ki-Woong Lee;Hak-Sung Kim .Optimization of microencapsulation of seed oil by response surface methodology[J].Food Chemistry,2008(1):98-105. |
| [20] | 徐晓军.化学絮凝剂作用原理[M].北京:科学出版社,2005:189-194. |
| [21] | 童洋,肖国民,潘晓梅.响应面法优化螺旋藻中叶绿素的超声提取工艺[J].化工学报,2009(11):2813-2819. |
| [22] | 朱哲,李涛,王东升,姚重华,汤鸿霄.阳离子型聚丙烯酰胺投加量对絮体性状特征的影响[J].环境化学,2007(02):175-179. |
| [23] | 任元元,康建平,黄静,苏波,夏兵兵.PAC絮凝枯草芽孢杆菌的主要工艺参数研究[J].食品与发酵科技,2011(02):42-45. |
| [24] | 谢微;何星存;黄智 等.单宁絮凝煮茧废水工艺的响应面优化参数分析[J].环境工程,2010,28(增刊1):114-118. |
| [25] | 郑怀礼,焦世珺,邓晓莉,冯力,张会琴,陈容.响应面法优化聚磷硫酸铁的制备及其应用[J].环境工程学报,2012(01):9-14. |
| [26] | 胡家玮,李军,于凤芹,王昌稳,李研,刘国洋.磁絮凝法处理河水工艺条件的响应面分析[J].北京工业大学学报,2013(03):459-465. |
| [27] | 李璐,杨朝晖,孙珮石,黄兢,曾光明,周长胜.基于响应面优化条件下柚皮对Pb2+的吸附[J].环境科学学报,2009(07):1426-1433. |
| [28] | 黄兢,杨朝晖,孙佩石,曾光明,周长胜,阮敏.微生物絮凝剂与聚合氯化铝复配的响应面优化[J].中国环境科学,2008(11):1014-1019. |
| [29] | 李家元,吴彦瑜,周少奇.响应曲面法优化絮凝处理木薯淀粉废水[J].环境工程学报,2010(07):1555-1560. |
| [30] | 高万超,杨朝晖,黄兢,邓久华,徐海音,谢华明.微生物絮凝剂捕集Cu（Ⅱ）的响应面优化及机理研究[J].环境工程学报,2011(11):2411-2416. |
| [31] | 李延吉,降向正,申波,刘立新,张旭,曹敏,赵絮颖.夹皮沟矿业公司干堆氰化尾矿淋溶液的治理与应用实践[J].黄金,2013(06):63-67. |
- 下载量()
- 访问量()
- 您的评分：
-
10%
-
20%
-
30%
-
40%
-
50%